VW Passat B5

since 1996 release

Repair and operation of the car



Foltsvagen Passat B5
+ Maintenance instruction
- 1. Maintenance
   1.1. Technical characteristics
   - 1.2. Frequency of service
      - 1.2.1. Weekly checks and service in way
         1.2.1.2. If the engine is not started and the starter does not work
         1.2.1.3. If the engine is not started even if the starter works normally
         1.2.1.4. Towage
         1.2.1.5. Replacement of a wheel
         1.2.1.6. Check of tightness of connections
         + 1.2.1.7. Places of weekly checks
         1.2.1.8. Identification data of the car
   + 1.3. Engine oil
   1.4. Check of the exhaust system
   + 1.5. Engine cooling system
   + 1.6. Spark plugs
   1.7. Discharge of water from the fuel filter (diesel engines)
   1.8. Replacement of the fuel filter (diesel engines)
   1.9. Check of tightness of hoses and effluence of liquid
   1.10. Replacement of the filtering element of the air filter
   1.11. Check of a condition of a poliklinovy belt
   1.12. Maple belts
   1.13. Measurement of wear of gear belts on diesel engines
   1.14. Box of transfers / main transfer
   1.15. Check of a protective cover of a power shaft
   1.16. Visual check of tightness of the transmission
   1.17. Check of level of oil in the mechanical transmission
   1.18. Check of oil in the main transfer of automatic transmissions
   1.19. Check/replacement of level of oil in the automatic transmission
   1.20. Check of a forward suspension bracket and steering
   1.21. Check of dustproof covers of hinges of a forward suspension bracket
   1.22. Check of the shock-absorber
   1.23. Check of a radiator
   1.24. Check of electric chains
   + 1.25. Brake fluid
   1.26. Check of front brake shoes
   1.27. Check of back brake shoes
   1.28. Check of brake hoses
   1.29. Check of cables of the emergency brake
   1.30. Check of level of liquid in the amplifier of steering
   1.31. Dust filter
   1.32. Rechargeable battery
   1.33. Hinges of doors
   + 1.34. Windscreen washers
   1.35. Brushes of screen wipers
   1.36. Check of a starting position of the lever of a screen wiper
   1.37. Check of a tilt angle of the lever of a screen wiper
   1.38. Replacement of the battery in a key of remote control
   1.39. Zeroing of the Service-indicator
+ 2. Engines
+ 3. Cooling system
+ 4. Fuel system
+ 5. Engine management
+ 6. Exhaust system
+ 7. Transmission
+ 8. Running gear
+ 9. Steering
+ 10. Brake system
+ 11. Body
+ 12. Heating, ventilation
+ 13. Electric equipment






1.2.1. Weekly checks and service in way

1.2.1.1. Start from an external source (other car)

GENERAL INFORMATION

Prevention

Before connection of the external accumulator make sure that ignition is switched off.

Make sure that all electric equipment (headlights, heating devices, screen wipers etc.) are switched off.

Take all special precautions ordered on the accumulator into account.

Cars should not concern each other.

Make sure that the lever of gear shifting is in neutral situation (or PARK in case of the automatic transmission).



PERFORMANCE ORDER
1. Connect one end of a red wire of big section to the positive plug of the discharged accumulator.
2. Connect other end of a red wire to the positive plug of the external accumulator.
3. Connect one end of a black wire of big section to the negative plug of the external accumulator.

4. Connect other end of a black wire of big section to the power unit or an element of a body of the started car far away from the accumulator.
5. Make sure that wires do not contact with вентилято rum, driving belts or other rotating parts of the car.
6. Start the engine, using an external source (at the same time the engine of the car source has to idle).
7. After start of the engine of the car with the discharged accumulator disconnect wires in the return sequence.