VW Passat B5

since 1996 release

Repair and operation of the car



Foltsvagen Passat B5
+ Maintenance instruction
- 1. Maintenance
   1.1. Technical characteristics
   + 1.2. Frequency of service
   + 1.3. Engine oil
   1.4. Check of the exhaust system
   + 1.5. Engine cooling system
   + 1.6. Spark plugs
   1.7. Discharge of water from the fuel filter (diesel engines)
   1.8. Replacement of the fuel filter (diesel engines)
   1.9. Check of tightness of hoses and effluence of liquid
   1.10. Replacement of the filtering element of the air filter
   1.11. Check of a condition of a poliklinovy belt
   1.12. Maple belts
   1.13. Measurement of wear of gear belts on diesel engines
   1.14. Box of transfers / main transfer
   1.15. Check of a protective cover of a power shaft
   1.16. Visual check of tightness of the transmission
   1.17. Check of level of oil in the mechanical transmission
   1.18. Check of oil in the main transfer of automatic transmissions
   1.19. Check/replacement of level of oil in the automatic transmission
   1.20. Check of a forward suspension bracket and steering
   1.21. Check of dustproof covers of hinges of a forward suspension bracket
   1.22. Check of the shock-absorber
   1.23. Check of a radiator
   1.24. Check of electric chains
   + 1.25. Brake fluid
   1.26. Check of front brake shoes
   1.27. Check of back brake shoes
   1.28. Check of brake hoses
   1.29. Check of cables of the emergency brake
   1.30. Check of level of liquid in the amplifier of steering
   1.31. Dust filter
   1.32. Rechargeable battery
   1.33. Hinges of doors
   + 1.34. Windscreen washers
   1.35. Brushes of screen wipers
   1.36. Check of a starting position of the lever of a screen wiper
   1.37. Check of a tilt angle of the lever of a screen wiper
   1.38. Replacement of the battery in a key of remote control
   1.39. Zeroing of the Service-indicator
+ 2. Engines
+ 3. Cooling system
+ 4. Fuel system
+ 5. Engine management
+ 6. Exhaust system
+ 7. Transmission
+ 8. Running gear
+ 9. Steering
+ 10. Brake system
+ 11. Body
+ 12. Heating, ventilation
+ 13. Electric equipment






1.18. Check of oil in the main transfer of automatic transmissions

GENERAL INFORMATION

Arrangement of a stopper of an oil-filling opening on the transmission 01N


Arrangement of a stopper of an oil-filling opening on the transmission 01V


For check of level of oil in the automatic 4-hstupenchaty transmission 01N (in combination with the 4-htsilindrovy engine, except the 150 hp engines) it is necessary to use a hexagon of 12 mm.

For check of level of oil in the automatic 4-hstupenchaty transmission 01V in combination with the 150 hp 4-htsilindrovy engine it is necessary to use new consolidation for a carving stopper of an oil-filling mouth.


Prevention

If when checking level in the main transfer of the transmission it is established that oil in the main transfer is too much or too little, then there is an exchange of oil with the planetary transmission. In this case it is necessary to address on VW service station for malfunction elimination.


PERFORMANCE ORDER
1. Install the car on the elevator in horizontal position.
2. Remove the lower mudguard of the engine.
3. Unscrew an oil-filling stopper from the transmission.
4. Check oil level. Oil level correct when it is on the lower edge of a carving opening.
5. Screw up a stopper of an oil-filling opening and tighten its moment 25 Nanometers on the transmission 01N and the moment of 30 Nanometers on the transmission 01V, see rice. An arrangement of a stopper of an oil-filling opening on the transmission 01N and rice. An arrangement of a stopper of an oil-filling opening on the transmission 01V.
6. Establish the lower mudguard of the engine.