canadian online pharmacies

VW Passat B5

since 1996 release

Repair and operation of the car



Foltsvagen Passat B5
+ Maintenance instruction
+ 1. Maintenance
+ 2. Engines
+ 3. Cooling system
+ 4. Fuel system
+ 5. Engine management
+ 6. Exhaust system
+ 7. Transmission
+ 8. Running gear
+ 9. Steering
+ 10. Brake system
+ 11. Body
+ 12. Heating, ventilation
- 13. Electric equipment
   13.2. General information
   + 13.3. Electric chains
   13.4. Safety locks
   13.5. Rules of care of the accumulator
   13.6. Check of the accumulator
   13.7. Accumulator charging
   13.8. Accumulator
   13.9. System of charging
   13:10. Generator
   13:11. Replacement of brushes of the generator and regulator of tension
   13:12. System of start of the engine
   13:13. Starter
   13:14. Traction relay of a starter
   13:15. Replacement of bulbs of external lighting
   13:16. Replacement of bulbs of internal lighting
   13:17. Devices of external lighting
   13:18. Executive engine of the proofreader of light of headlights
   13:19. Adjustment of light of headlights
   13:20. Gas-discharge lamps of headlights of passing beam
   13:21. Combination of devices
   13:22. Multipurpose switches of a steering column
   13:23. Switches
   13:24. Radio receiver
   13:25. High-frequency loudspeakers
   13:26. Low-frequency loudspeakers
   13:27. Antenna
   13:28. Check of a heater of back glass
   13:29. Windshield screen wiper engine
   13:30. Engine of a screen wiper of back glass
   13:31. Windscreen washer pump
   13:32. System of the central blocking of locks
   13:33. Main malfunctions of the generator
   13:34. Main malfunctions of a starter
   + 13:35. Electric circuits







13:22. Multipurpose switches of a steering column

GENERAL INFORMATION

Arrangement of screws in the lower casing of a steering column

1 – top casing of a steering column

Arrangement of screws of fastening of the lower casing of a steering column

1 – bolt,
2 – lock handle of an adjustable steering column,
3 – lower casing of a steering column

Removal

PERFORMANCE ORDER
1. Switch off ignition and remove a weight wire from the accumulator.
2. Remove a safety cushion from the central part of a steering wheel.
3. Establish a steering wheel for the movement directly forward.
4. Unscrew the central bolt of fastening (2) of a steering wheel (1) and remove a steering wheel.
5. Unscrew two screws from the lower casing of a steering column, see rice. An arrangement of screws in the lower casing of a steering column.
6. Remove the top casing (1) of a steering column, see rice. An arrangement of screws in the lower casing of a steering column.
7. Unscrew four screws fixing the lower casing of a steering column see rice. Arrangement of screws of fastening of the lower casing of a steering column.
8. Using a six-sided key, unscrew the screw (1), see rice. Arrangement of screws of fastening of the lower casing of a steering column.
9. Remove the lower casing of a steering column.
Weaken a bolt of fastening of multipurpose switches on a steering column.
10. Disconnect electric sockets from multipurpose switches. Keep in mind that the spiral spring remains on the multipurpose switch of a steering column therefore at removal do not turn a spring from average situation.
11. Remove multipurpose switches.

Installation

Installation of the multipurpose switch

1 – steering wheel,
2 – multipurpose switch,
3 – bolt of fastening of the switch,

and = 3 mm


PERFORMANCE ORDER
1. Install the multipurpose switch on a steering column, but at this stage on tighten a bolt of fastening of the multipurpose switch.
2. Establish a steering wheel.
3. Moving, install многофункцио the nalny switch (2) in such situation that the distance (a) between a steering wheel (1) and the multipurpose switch made 3 mm, see rice. Installation of the multipurpose switch.
4. Remove a steering wheel and establish the lower and top casings of a steering column.
5. Establish a steering wheel.
6. Establish a safety cushion in the central part of a steering wheel.
7. Connect a weight wire to the accumulator.