VW Passat B5

since 1996 release

Repair and operation of the car



Foltsvagen Passat B5
+ Maintenance instruction
+ 1. Maintenance
+ 2. Engines
+ 3. Cooling system
+ 4. Fuel system
+ 5. Engine management
+ 6. Exhaust system
+ 7. Transmission
+ 8. Running gear
+ 9. Steering
+ 10. Brake system
+ 11. Body
+ 12. Heating, ventilation
- 13. Electric equipment
   13.2. General information
   + 13.3. Electric chains
   13.4. Safety locks
   13.5. Rules of care of the accumulator
   13.6. Check of the accumulator
   13.7. Accumulator charging
   13.8. Accumulator
   13.9. System of charging
   13:10. Generator
   13:11. Replacement of brushes of the generator and regulator of tension
   13:12. System of start of the engine
   13:13. Starter
   13:14. Traction relay of a starter
   13:15. Replacement of bulbs of external lighting
   13:16. Replacement of bulbs of internal lighting
   13:17. Devices of external lighting
   13:18. Executive engine of the proofreader of light of headlights
   13:19. Adjustment of light of headlights
   13:20. Gas-discharge lamps of headlights of passing beam
   13:21. Combination of devices
   13:22. Multipurpose switches of a steering column
   13:23. Switches
   13:24. Radio receiver
   13:25. High-frequency loudspeakers
   13:26. Low-frequency loudspeakers
   13:27. Antenna
   13:28. Check of a heater of back glass
   13:29. Windshield screen wiper engine
   13:30. Engine of a screen wiper of back glass
   13:31. Windscreen washer pump
   13:32. System of the central blocking of locks
   13:33. Main malfunctions of the generator
   13:34. Main malfunctions of a starter
   + 13:35. Electric circuits






13:21. Combination of devices

GENERAL INFORMATION

Arrangement of electric sockets on a back part of a combination of devices


1 – 34-contact electric socket of green color,
2 – the 20-contact electric socket of red color (is established only on the 3rd option of execution),
3 – control lamp of driving beam of 1,12 W,
4 – control lamp of exhaust gases of 1,12 W,
5 – control lamp of work of turns of the trailer of 1,12 W,
6 – 32-contact electric socket of blue color

Arrangement of screws of fastening of a combination of devices


Removal

Removal of the lower side finishing from the driver


1 – cap,
2 – screw,
3 – screw,
4 – side finishing

Removal of the lower panel of finishing of the dashboard from the driver

1 – side cover,
2 – lower panel of finishing,
3 – light switch,
4 – proofreader of light of headlights

Shooters noted an arrangement of screws of fastening of the lower panel of finishing.

Removal of decorative facing under a combination of devices

1 – facing inside,
2 – clip,
3 – decorative facing

Prevention

In a combination of devices it is possible to make only replacement of control bulbs of an incandescence. At failure of one of indexes or with any other defect the combination of devices needs to be replaced assembled.


PERFORMANCE ORDER
1. Remove switches of a steering column.
2. Remove the lower side finishing from the driver for what remove the caps closing fastening screws, and unscrew screws, see rice. Removal of the lower side finishing from the driver. Move forward and remove the lower side finishing from the driver.
3. Remove the lower finishing of the dashboard from the driver. Remove a side decorative slip from the left end face of the dashboard.
4. Unscrew screws (shooters) fixing the lower panel of finishing of the dashboard from the driver see rice. Removal of the lower panel of finishing of the dashboard from the driver.
5. Disconnect electric sockets from the switch of light of headlights and the proofreader of light of headlights.
6. Raise from the inside decorative facing (1) and, using a rigid clip (2), record it in this situation, see rice. Removal of decorative facing under a combination of devices.
7. Unscrew 4 screws and remove decorative facing, see rice. Removal of decorative facing under a combination of devices.
8. In the lower part of a combination of devices unscrew two screws and remove a combination of devices, see rice. Arrangement of screws of fastening of a combination of devices.
9. Disconnect from a back part of a combination of devices electric sockets, see rice. An arrangement of electric sockets on a back part of a combination of devices.
10. If necessary replace glow lamps.

Installation

PERFORMANCE ORDER
1. Installation is made in the sequence, the return to removal.
2. If the new combination of devices is established modify indications of the Service-indicator and the counter of kilometers.