VW Passat B5

since 1996 release

Repair and operation of the car



Foltsvagen Passat B5
+ Maintenance instruction
+ 1. Maintenance
+ 2. Engines
+ 3. Cooling system
+ 4. Fuel system
+ 5. Engine management
+ 6. Exhaust system
+ 7. Transmission
+ 8. Running gear
+ 9. Steering
+ 10. Brake system
- 11. Body
   11.2. Care of a body
   11.3. Care of an upholstery and rugs
   11.4. Repair of insignificant damages of a body
   11.5. Repair of strong damages of a body
   + 11.6. Forward cross panel
   11.7. Front bumper
   11.8. Removal of the lever of blocking of a cowl
   11.9. Adjustment of the side directing bumper arm
   11:10. Rear bumper
   11:11. Forward wing
   11:12. Facing of a niche of a forward wheel
   11:13. Air inlet lattice
   + 11:14. Cowl
   11:15. Front grille
   + 11:16. Cable of opening of the lock of a cowl
   11:17. Cowl lock
   11:18. Internal finishing of a door
   11:19. Differences at removal of an upholstery of the right forward door
   11:20. Control unit of door mechanisms
   11:21. Consolidation of a door
   11:22. Side finishing of the luggage compartment of the Sedan models
   11:23. Side finishing of the luggage compartment of the Station wagon models
   11:24. Back finishing of the luggage compartment on the Sedan models
   11:25. Trunk lid upholstery
   11:26. Luggage carrier door upholstery
   11:27. A covering of half of the luggage compartment on the Station wagon models
   11:28. Trunk lid
   + 11:29. Luggage carrier lock
   11:30. Adjustment of provision of a cover of a luggage carrier / back door
   + 11:31. The lock of a back door on the Station wagon models
   11:32. Forward door
   11:33. Cylinder of the lock of a forward door
   11:34. External handle of opening of a door
   11:35. Door lock
   11:36. Manual lowering of glass of a door
   11:37. Door glass
   11:38. Door arm
   11:39. Internal rear-view mirror
   11:40. Central console
   11:41. Forward ashtray
   11:42. Back ashtray
   11:43. Decorative overlay of the lever (automatic transmission)
   11:44. Decorative slips under the radio receiver
   11:45. The lower finishing of the dashboard from the driver
   11:46. Ware box
   11:47. Internal decorative overlay of an external rear-view mirror
   11:48. Ceiling handle
   11:49. Antisolar peaks
   11:50. Overlays of thresholds
   11:51. Wind and back flew down
   11:52. Sitting lobbies
   11:53. Head restraint
   11:54. Side safety cushions
   11:55. Back sitting
   11:56. Left back of back sitting
   11:57. Carpet
   11:58. Elements of finishing of an interior
   11:59. External mirror of a back type / glass of a mirror
   11.60. Case of an external mirror
   11.61. Protection / бордюрная roof level
   11.62. Side overlay of a body
   11.63. Replacement of rubber tapes of brushes of screen wipers
   11.64. Nozzles of washers of a windshield
   11.65. Screen wiper levers
+ 12. Heating, ventilation
+ 13. Electric equipment






11.64. Nozzles of washers of a windshield

Removal

The direction of pressing windshield washer nozzles for its removal from a cowl


PERFORMANCE ORDER
1. Open a cowl.
2. A hand press spray nozzles in the direction of the movement of the car and in this situation move nozzles down and take it from a cowl, see rice. The direction of pressing windshield washer nozzles for its removal from a cowl.
3. Disconnect a liquid supply hose from a nozzle.
4. Separate a wire of a heater of a nozzle of a washer of a windshield from a cowl and disconnect the electric socket from a heater.

Installation

PERFORMANCE ORDER
1. Dress a liquid supply hose on nozzles.
2. Connect the electric socket to a heater of a nozzle and fix a wire on a cowl.
3. Pressing washer nozzles, record it in a cowl.
4. Check the direction of a stream of the liquid sprayed on a windshield and, if necessary, adjust washer nozzles.

Adjustment

The correct dispersion of liquid on a windshield


The clown's arrangement for adjustment of the sprayed liquid stream on height



The direction of turn of jets in nozzles of a washer of back glass on the Station wagon models


Arrangement of points of supply of liquid on glass of a left headlight

And = 60 mm
In = 205 mm
With = 75 mm
D = 80 mm

On the cars manufactured to XII.96 situation snuffled a washer it is not regulated. If the stream of the liquid sprayed by nozzles is at the different height of a windshield, it is necessary to replace washer nozzles with adjustable nozzles of a washer which are established on models from I.97, see rice. The correct dispersion of liquid on a windshield.

On the cars manufactured with I.97 adjustable nozzles of washers which allow to regulate the sprayed liquid stream on height are established. For this purpose in the basis of a nozzle the clown is established. At turn of the clown counterclockwise the liquid stream sprayed by a nozzle rises up, see rice. The clown's arrangement for adjustment of the sprayed liquid stream on height.

Nozzles of a washer of back glass on the Station wagon models has to give a liquid stream to the center of back glass. The direction of a stream can be regulated, turning jets a needle or a shaft of a drill with a diameter of 0,8 mm, see rice. The direction of turn of jets in nozzles of a washer of back glass on the Station wagon models.

If the direction of a stream of the liquid sprayed by a nozzle is not regulated, or the stream of liquid is uneven, replace washer nozzles.

If necessary, blow washer nozzles compressed air. For this purpose remove nozzles and blow it from connection of a hose.


Prevention

Do not blow a nozzle in the direction, the return to liquid supply.


Adjust nozzles of washers of headlights so that liquid was sprayed on glass of headlights in the points shown on rice. An arrangement of points of supply of liquid on glass of a left headlight.
Chicago History.