VW Passat B5

since 1996 release

Repair and operation of the car



Foltsvagen Passat B5
+ Maintenance instruction
+ 1. Maintenance
+ 2. Engines
+ 3. Cooling system
+ 4. Fuel system
+ 5. Engine management
+ 6. Exhaust system
+ 7. Transmission
+ 8. Running gear
+ 9. Steering
+ 10. Brake system
- 11. Body
   11.2. Care of a body
   11.3. Care of an upholstery and rugs
   11.4. Repair of insignificant damages of a body
   11.5. Repair of strong damages of a body
   + 11.6. Forward cross panel
   11.7. Front bumper
   11.8. Removal of the lever of blocking of a cowl
   11.9. Adjustment of the side directing bumper arm
   11:10. Rear bumper
   11:11. Forward wing
   11:12. Facing of a niche of a forward wheel
   11:13. Air inlet lattice
   + 11:14. Cowl
   11:15. Front grille
   + 11:16. Cable of opening of the lock of a cowl
   11:17. Cowl lock
   11:18. Internal finishing of a door
   11:19. Differences at removal of an upholstery of the right forward door
   11:20. Control unit of door mechanisms
   11:21. Consolidation of a door
   11:22. Side finishing of the luggage compartment of the Sedan models
   11:23. Side finishing of the luggage compartment of the Station wagon models
   11:24. Back finishing of the luggage compartment on the Sedan models
   11:25. Trunk lid upholstery
   11:26. Luggage carrier door upholstery
   11:27. A covering of half of the luggage compartment on the Station wagon models
   11:28. Trunk lid
   + 11:29. Luggage carrier lock
   11:30. Adjustment of provision of a cover of a luggage carrier / back door
   + 11:31. The lock of a back door on the Station wagon models
   11:32. Forward door
   11:33. Cylinder of the lock of a forward door
   11:34. External handle of opening of a door
   11:35. Door lock
   11:36. Manual lowering of glass of a door
   11:37. Door glass
   11:38. Door arm
   11:39. Internal rear-view mirror
   11:40. Central console
   11:41. Forward ashtray
   11:42. Back ashtray
   11:43. Decorative overlay of the lever (automatic transmission)
   11:44. Decorative slips under the radio receiver
   11:45. The lower finishing of the dashboard from the driver
   11:46. Ware box
   11:47. Internal decorative overlay of an external rear-view mirror
   11:48. Ceiling handle
   11:49. Antisolar peaks
   11:50. Overlays of thresholds
   11:51. Wind and back flew down
   11:52. Sitting lobbies
   11:53. Head restraint
   11:54. Side safety cushions
   11:55. Back sitting
   11:56. Left back of back sitting
   11:57. Carpet
   11:58. Elements of finishing of an interior
   11:59. External mirror of a back type / glass of a mirror
   11.60. Case of an external mirror
   11.61. Protection / бордюрная roof level
   11.62. Side overlay of a body
   11.63. Replacement of rubber tapes of brushes of screen wipers
   11.64. Nozzles of washers of a windshield
   11.65. Screen wiper levers
+ 12. Heating, ventilation
+ 13. Electric equipment






11:50. Overlays of thresholds

GENERAL INFORMATION

Elements of internal finishing of an aperture of a back door

1 – decorative slip,
2 – nut,
3 – the screw with a safety lock,
4 – clip,
5 – clamp,
6 – clamp ledge,
7 – overlay of a threshold

Elements of fastening of an upholstery of a back rack

1 – screw,
2 – upholstery,
3 – clip

Elements of fastening of finishing of the lower part of a forward rack

1 – cap,
2 – screw,
3 – screw,
4 – finishing panel

Elements of fastening of an overlay of a threshold

1 – screw,
2 – plastic nut,
3 – overlay of a threshold,
4 – door sealant,
5 – clip

Removal

PERFORMANCE ORDER
1. Release clamps and incline a back of back sitting forward.
2. Weaken a nut (2) and unscrew a bolt (3) with a safety lock, see rice. Elements of internal finishing of an aperture of a back door.
3. Take the top part of a decorative slip from a clip (4), then in the lower part release a ledge of a clamp (6) from an overlay of a threshold (7) and remove a decorative slip (1) together with a clamp (5).
4. Unscrew the screws (1) fixing a covering (2) back racks see rice. Elements of fastening of an upholstery of a back rack.
5. Remove the lower finishing of a forward rack for what remove the caps closing screws, then unscrew screws and, having pulled forward, take finishing from under an overlay of a threshold and remove it from the car, see rice. Elements of fastening of finishing of the lower part of a forward rack.
6. Unscrew the screw (1) fixing a back part of an overlay of a threshold see rice. Elements of fastening of an overlay of a threshold.
7. Having pulled up, release the clips fixing an overlay of thresholds to a car body and remove an overlay of thresholds from the car.

Installation

PERFORMANCE ORDER
1. Before installation check a condition of clips of an overlay of thresholds and plastic nuts and, if necessary, replace them.
2. Installation is made in the sequence, the return to removal.
3. Check correctness of an arrangement of a sealant of a door.